Volvo 740 GL Especificações

1986 Volvo 740 GL, GLE, Turbo 1 9 8 6 VOLVO 740 GL, GLE, Turbo Contents A comprehensive index is located at the back of this manual. Presentation In

1986 Volvo 740 GL, GLE, Turbo Oil pressure warning light If the light comes on during driving, the oil pressure is too low. Stop the car and then stop

1986 Volvo 740 GL, GLE, Turbo Touching up is as follows: 1. Remove paint flakes. 2.Sand the damaged surface and wash it clean with thinner. Apply th

1986 Volvo 740 GL, GLE, Turbo fenders, etc.) In areas of high industrial pollution more frequent washing is also recommended.Suitable detergents Speci

1986 Volvo 740 GL, GLE, Turbo Normally, polishing is not required during the first year after delivery, however, waxing may be beneficial. Before app

1986 Volvo 740 GL, GLE, Turbo ● Take extra care when removing stains such as ink or lipstick since the coloring can spread. ● Use solvents spa

1986 Volvo 740 GL, GLE, Turbo 1 9 8 6 VOLVO 740 GL, GLE, Turbo Volvo Service pg. 91 Service - an investment! An investment which will pay dividends

1986 Volvo 740 GL, GLE, Turbo Cooling System Hoses and ConnectionsI I I Engine Drive Belts A I

1986 Volvo 740 GL, GLE, Turbo Inspect Brakes. Replace components as necessary. I I I I I I Change Brake Fluid1

1986 Volvo 740 GL, GLE, Turbo qualified technician. To keep your Volvo in top condition, specify time tested and proven Genuine Volvo Parts and Access

1986 Volvo 740 GL, GLE, Turbo 4 Oil dipstick, engine 5 Brake fluid reservoir 6 Oil reservoir, power steering 7 Battery 8 Data plate 9 Engine identific

1986 Volvo 740 GL, GLE, Turbo much oil or excessive oil consumption will result. * if oil cooler (Turbo models) is drained, add 0.7 US qts (0.6 liter

1986 Volvo 740 GL, GLE, Turbo Obviously, there will be times when you need to shift later than the light would indicate (for example, when climbing hi

1986 Volvo 740 GL, GLE, Turbo ● Extended periods of idling and/or low-speed operation ● Frequent short trips (less than 7 miles = 11 km) ●

1986 Volvo 740 GL, GLE, Turbo LH Jetronic 2.2 fuel system The B230F engine (740 GL, GLE) and the B230F-Turbo engine (740 TUrbo) both have the same typ

1986 Volvo 740 GL, GLE, Turbo Torque Catalytic Converter mounting bolts The Catalytic Converter mounting bolts should be torqued after the first 600-1

1986 Volvo 740 GL, GLE, Turbo PCV system, 740 GLE (B230F engine) The PCV nipple in the intake manifold should be cleaned every 60,000 miles (96,000 km

1986 Volvo 740 GL, GLE, Turbo Capacity: 2.4 US qts (2.3 liters) Fluid type: Automatic Transmission Fluid Type F or G(FLM). Replace: at 600-1,200 mile

1986 Volvo 740 GL, GLE, Turbo At oil temperature below +105°F (+40°C), the level may be below the MIN mark.B Warm transmission: oil temperature +195°F

1986 Volvo 740 GL, GLE, Turbo No. Lubricating point Lubricant 1 Hood lock and latch Paraffin wax 2 Hood hinges Oil 3 Door stop Oil4 Sunroof wind d

1986 Volvo 740 GL, GLE, Turbo Every two years or 30,000 miles (48,000 km) the cooling system should be drained, flushed and refilled. Remove the expa

1986 Volvo 740 GL, GLE, Turbo Contents | Top of Page file:///K|/ownersdocs/1986/1986_740/86740_07.htm (15 of 15)12/30/2006 7:51:36 AM

1986 Volvo 740 GL, GLE, Turbo 1 9 8 6 VOLVO 740 GL, GLE, Turbo Specifications pg. 110 Specifications Dimensions and weights 740 GL, GLE 740 TURBO Le

1986 Volvo 740 GL, GLE, Turbo pg. 12 Turn signals, Hazard warning flasher Turn signals 1 Lane change position. In maneuvers such as lane changing, t

1986 Volvo 740 GL, GLE, Turbo Turbo (sedan) 2090 lbs. 950 kg Wagon 2310 lbs. 1050 kg Max. roof load 220 lbs. 100 kg Max. trailer weight 3300 lbs. 1

1986 Volvo 740 GL, GLE, Turbo The Vehicle Identification Number (VIN) should always be quoted in all correspondence concerning your vehicle with the d

1986 Volvo 740 GL, GLE, Turbo 6 Service label Label on left-rear door frame. Information on certain components. All specifications are subject to chan

1986 Volvo 740 GL, GLE, Turbo temperatures or excessive oil consumption e.g. mountain driving with frequent deceleration, or high-speed driving. Note,

1986 Volvo 740 GL, GLE, Turbo Number of cylinders 4 Bore 3.78" (96 mm) Stroke 3.15" (80 mm)Displacement 2.32 Liters Compression ratio 8.7:1V

1986 Volvo 740 GL, GLE, Turbo Spark plug gap 0.024-0.028" (0.6-0.7 mm)Tightening torque 15-22 ft. lbs. (20-30 Nm)Distributor, direction of rota

1986 Volvo 740 GL, GLE, Turbo Power transmission Manual or automatic transmission. Hypoid type Final drive. Manual transmission M46 Reduction ratios:

1986 Volvo 740 GL, GLE, Turbo 2nd gear 1.48:1 3rd gear 1:1 4th gear 0.73:1 Reverse 2.09:1 Rear Axle : Reduction ratios: 3.91:1Speeds at 1000 engin

1986 Volvo 740 GL, GLE, Turbo Voltage 12V Battery, type Maintenance freeCapacity 450 A, 90 min Electrolyte, specific gravity 1.28Recharge at 1.23Alter

1986 Volvo 740 GL, GLE, Turbo ashtray, rear 1.2 W Volvo P/N 966326 1Warning lights charging 1.2 W Volvo P/N 966326 1 oil pressure 1.2 W Volvo P/N 966

1986 Volvo 740 GL, GLE, Turbo NOTE: Defective turn signal bulb will cause turn signal indicator and remaining signal lights to flash more rapidly than

1986 Volvo 740 GL, GLE, Turbo WARNING! Improperly inflated tires will reduce tire life, adversely affect vehicle handling and can possibly lead to fai

1986 Volvo 740 GL, GLE, Turbo Service Manuals for your Volvo are available for purchase. These are the same manuals used by competent Volvo technician

1986 Volvo 740 GL, GLE, Turbo file:///K|/ownersdocs/1986/1986_740/86740_08.htm (14 of 14)12/30/2006 7:51:37 AM

1986 Volvo 740 GL, GLE, Turbo 1 9 8 6 VOLVO 740 GL, GLE, Turbo Index pg. 119-120 Specifications A Air conditioning 21, 22, 23 Air louvers 20 Alterna

1986 Volvo 740 GL, GLE, Turbo Chassis number 111 Check coolant 108 Check oil 97 Child safety 29 Child safety locks 33 Cigarette lighter 18 Climate con

1986 Volvo 740 GL, GLE, Turbo Emergency towing (pulling) 53 Engine number 95-96 Engine 95-96Engine oil 97-98 F Fan belts 109 Fault tracing 80 Federal

1986 Volvo 740 GL, GLE, Turbo Instrument and controls 4 Interior light 27 J Jack 68 Jump start 55 K Keys 3 Kick-down 49 L Label information 111 Licens

1986 Volvo 740 GL, GLE, Turbo Polishing 89 Power steering fluid 106 Power train 115 R Radios 24 Rear axle oil 104 Rear foglights 16 Rear view mirrors

1986 Volvo 740 GL, GLE, Turbo Tachometer 6 Tailgate (wagon) 37 Temperature gauge 6 Tire pressure 64 Tires 62 Tire wear indicator 63 Tools 117 Touch up

1986 Volvo 740 GL, GLE, Turbo Wheel alignment 115 Wheel change 67 Wheels and tires 62 Window lifts 19 Windshield washers13 Windshield wipers 13 Winter

1986 Volvo 740 GL, GLE, Turbo Wiper/washer 1 Intermittent wiper. With switch in this position, the wipers will sweep approximately every seventh secon

1986 Volvo 740 GL, GLE, Turbo file:///K|/ownersdocs/1986/1986_740/86740_09.htm (8 of 9)12/30/2006 7:51:38 AM

1986 Volvo 740 GL, GLE, Turbo Contents | Top of Page file:///K|/ownersdocs/1986/1986_740/86740_09.htm (9 of 9)12/30/2006 7:51:38 AM

1986 Volvo 740 GL, GLE, Turbo 1 The wiper operates continuously.2 Intermittent position: the wiper strokes approximately every 15 seconds.3 Tailgate w

1986 Volvo 740 GL, GLE, Turbo (optional on certain models) The cruise control switches are located on the turn signal switch lever. To engage and set

1986 Volvo 740 GL, GLE, Turbo Headlights and position lights All lights off Parking lights on Headlights and parking lights are on if starting (ig

1986 Volvo 740 GL, GLE, Turbo Rear fog lights The rear fog lights are considerably brighter than the normal tail lights and should be use only when at

1986 Volvo 740 GL, GLE, Turbo Power antenna (optional on certain models) The power antenna switch can be used to retract the antenna when the audio sy

1986 Volvo 740 GL, GLE, Turbo This Owner's manual provides information on driving and maintaining your Volvo It should be noted that there are c

1986 Volvo 740 GL, GLE, Turbo Heated front seats (certain models) The front seats are equipped with electrically-heated backrests and seat cushions. T

1986 Volvo 740 GL, GLE, Turbo Cigarette lighter To operate, depress the knob fully. When the knob automatically releases, the cigarette lighter is rea

1986 Volvo 740 GL, GLE, Turbo Electrically-operated windows (certain models) The electrically operated windows are controlled by switches from the dri

1986 Volvo 740 GL, GLE, Turbo The rear door windows cannot be raised or lowered with the respective door switch but instead only with the correspondi

1986 Volvo 740 GL, GLE, Turbo C Directing air flow horizontally D Directing air flow vertically pg. 21 Heating and ventilation Heating and ventilation

1986 Volvo 740 GL, GLE, Turbo NOTE: A certain amount of air will always enter through the dash air louvers as long as they are open; independent of th

1986 Volvo 740 GL, GLE, Turbo NOTE: A certain amount of air will always enter through the dash air louvers as long as they are open; independent of t

1986 Volvo 740 GL, GLE, Turbo ● The air conditioning compressor is engaged only if the temperature is above 46°F (+8°C). ● In all three air co

1986 Volvo 740 GL, GLE, Turbo The diagram above identifies the controls and indicators for Audio/Cassette Tuner TD-3141. For complete operating instru

1986 Volvo 740 GL, GLE, Turbo 1 9 8 6 VOLVO 740 GL, GLE, Turbo Body and interior pg. 25 Body and interior The seats, seat belts, doors, etc. are des

1986 Volvo 740 GL, GLE, Turbo The key number codes are stamped on a separate tag supplied with the keys. This tag should be separated from the key rin

1986 Volvo 740 GL, GLE, Turbo Rear-view mirror A Normal position B Night position, reduces glare from following headlights Side-view mirrors Use the

1986 Volvo 740 GL, GLE, Turbo Make-up mirror The make-up mirror is located on the right-side sun visor. Make-up mirror lighting: (certain models only)

1986 Volvo 740 GL, GLE, Turbo Sun roof (certain models) The sun roof can be used in two ways: as a conventional sliding roof, or the rear edge can be

1986 Volvo 740 GL, GLE, Turbo Height adjustment The front section of the seats can be adjusted to three height positions and the rear section to four.

1986 Volvo 740 GL, GLE, Turbo information. ● In using any child restraint system, we urge you to look carefully over the instructions that are pro

1986 Volvo 740 GL, GLE, Turbo In order for the seat belt to provide maximum protection in the event of an accident, it must be worn correctly. When we

1986 Volvo 740 GL, GLE, Turbo Center-rear belt adjustment The center-rear seat belt is manually adjustable. It should always be adjusted to the correc

1986 Volvo 740 GL, GLE, Turbo During pregnancy Pregnant women should always wear seat belts. Remember that the belt should always be positioned in suc

1986 Volvo 740 GL, GLE, Turbo The driver's door can be locked only by using the key when outside the vehicle. CAUTION! The lock buttons should no

1986 Volvo 740 GL, GLE, Turbo The buttons are located on the rear door jambs. A The door lock functions normally. B The door cannot be opened from t

1986 Volvo 740 GL, GLE, Turbo 1 9 8 6 VOLVO 740 GL, GLE, Turbo Instruments and controls pg. 4 Instruments, Switches and controls pg. 5 Instruments,

1986 Volvo 740 GL, GLE, Turbo pg. 34 Trunk, Long load storage (sedan) Trunk light A Light always off. file:///K|/ownersdocs/1986/1986_740/86740_02.

1986 Volvo 740 GL, GLE, Turbo B Light is on when trunk lid is opened. WARNING! When braking rapidly the load could be displaced and cause injury to oc

1986 Volvo 740 GL, GLE, Turbo To open the hood Pull the release handle (located under the left side of the dash). Lift the hood slightly, insert a ha

1986 Volvo 740 GL, GLE, Turbo Engine compartment light A the light is always off B the light comes on when the hood is opened. pg. 36 Storage spaces

1986 Volvo 740 GL, GLE, Turbo WARNING! Packages on the rear window shelf can obscure vision and may become dangerous projectiles in the even of a sudd

1986 Volvo 740 GL, GLE, Turbo To open the tailgate from the inside of the vehicle, move the handle to the left and push outwards. Child safety lock

1986 Volvo 740 GL, GLE, Turbo Tool box The tool box can be released by turning the catch. pg. 39 Folding rear seat (wagon) file:///K|/ownersdocs/1

1986 Volvo 740 GL, GLE, Turbo Folding rear seat: increasing the cargo space The rear seat is split 60/40 so that each section can be folded independen

1986 Volvo 740 GL, GLE, Turbo Important: Make sure that the latches on the underneath of the seat cushions engage holes at top edge of backrest. Make

1986 Volvo 740 GL, GLE, Turbo fold the seat completely as the retaining pins will then be difficult to remove.) Remove the seat cushion. WARNING! Unle

1986 Volvo 740 GL, GLE, Turbo 8 Heating and ventilation 20 9 Audio cassette/tuner24 10 Cigarette lighter18 11 Ash tray 18 12 Electrically-heated passe

1986 Volvo 740 GL, GLE, Turbo Cargo space lighting There is an extra courtesy light at the rear of the cargo space. 1 Light comes on when the tailgate

1986 Volvo 740 GL, GLE, Turbo 1 9 8 6 VOLVO 740 GL, GLE, Turbo Starting and driving pg. 42 Starting and driving. Break-in period This section on sta

1986 Volvo 740 GL, GLE, Turbo Manual transmission Do not exceed following speeds:* First 600 miles(1,000 km) 600-1,200 miles(1,000-2,000 km)Gear mph

1986 Volvo 740 GL, GLE, Turbo economy with gasohol, you should discontinue its use. Take care not to spill gasoline during refueling. Gasolines contai

1986 Volvo 740 GL, GLE, Turbo air conditioner's compressor places on additional load on the engine. Other factors which decrease gas mileage are:

1986 Volvo 740 GL, GLE, Turbo operating temperature as soon as possible. This is best achieved by driving with a light foot on the accelerator pedal f

1986 Volvo 740 GL, GLE, Turbo The overdrive is automatically disengaged when downshifting from 4th gear, but you should always disengage the overdrive

1986 Volvo 740 GL, GLE, Turbo AW71 tranmission (Turbo models) ZF transmission (GL, GLE models) Gear selector positions P park R reverse N neutral D d

1986 Volvo 740 GL, GLE, Turbo D is the normal driving position. Upshifts and downshifts of the forward gears occur automatically and are governed by a

1986 Volvo 740 GL, GLE, Turbo Shift gate: AW71 transmission (Turbo models) The gear selector can be moved freely between D and 2. Selections of other

1986 Volvo 740 GL, GLE, Turbo NOTE: Canadian model speedometers/odometers indicate kilometers only.1 Voltmeter (Turbo models) 2 Fuel gauge 3 Clock re

1986 Volvo 740 GL, GLE, Turbo 4th gear disengagement: AW71 transmission(Turbo models) The 4th gear is engaged automatically after the transmission has

1986 Volvo 740 GL, GLE, Turbo NOTE: ● Never select P or R while the car is in motion. ● When initially selecting positions D, 3, 2, 1, or R th

1986 Volvo 740 GL, GLE, Turbo Disengage position D by selecting gear position 3. This prevents upshifts to Drive and helps ensure lower transmission o

1986 Volvo 740 GL, GLE, Turbo cables of the alternator must be disconnected and the welder cables placed as near the welding point as possible. WARNIN

1986 Volvo 740 GL, GLE, Turbo Roof racks (removable and permanent) Roof racks are available as Volvo accessories. Observe the following points when i

1986 Volvo 740 GL, GLE, Turbo CAUTION: The towing eyelets must not be used for pulling another vehicle out of a ditch or any similar purpose involving

1986 Volvo 740 GL, GLE, Turbo CAUTION: Improper hook-up of jumper cables or use of other than 12-volt batteries could result in damage to equipment an

1986 Volvo 740 GL, GLE, Turbo ● Keep your engine properly tuned. Certain engine malfunctions, particularly involving the electrical, fuel or ignit

1986 Volvo 740 GL, GLE, Turbo The pedal stroke increases slightly and the pedal feels softer but the pedal pressure required does not increase noticea

1986 Volvo 740 GL, GLE, Turbo When preparing for trailer hauling, observe the following: ● Use a trailer hitch which meets Federal Safety Standard

1986 Volvo 740 GL, GLE, Turbo Trip odometer Used form measuring shorter distances. (last figure represents 1/10 mile or 1/10 km) Trip odometer reset

1986 Volvo 740 GL, GLE, Turbo Note: Refer to section entitled "Automatic transmission" for additional trailer hauling tips. pg. 59 Winter

1986 Volvo 740 GL, GLE, Turbo Before a long distance trip It is always worthwhile to have your car checked at a Volvo dealer before driving long dista

1986 Volvo 740 GL, GLE, Turbo ● Wash the car carefully and wax it to protect the paint - don't forget the chromed parts. ● The vehicle sh

1986 Volvo 740 GL, GLE, Turbo 1 9 8 6 VOLVO 740 GL, GLE, Turbo Wheels and tires pg. 62 Wheels and tires The handling and riding comfort of the vehic

1986 Volvo 740 GL, GLE, Turbo pg. 63 Wheels and tires Wear indicator The tires have a so-called "wear indicator" in the form of a number of

1986 Volvo 740 GL, GLE, Turbo have the same rotational direction throughout their entire lifetime. In other words, if you wish to rotate the wheels, m

1986 Volvo 740 GL, GLE, Turbo Contents | Top of Page file:///K|/ownersdocs/1986/1986_740/86740_04.htm (4 of 4)12/30/2006 7:51:31 AM

1986 Volvo 740 GL, GLE, Turbo 1 9 8 6 VOLVO 740 GL, GLE, Turbo In case of emergency pg. 65 In case of emergency Even if you maintain your car in goo

1986 Volvo 740 GL, GLE, Turbo WARNING! Current legislation prohibits the use of the "Special Spare" tire other than as a temporary replaceme

1986 Volvo 740 GL, GLE, Turbo ● With the car still on the ground, use the box wrench from the tool kit to loosen the wheel nuts 1/2 - 1 turn. Turn

1986 Volvo 740 GL, GLE, Turbo pg. 8 Indicator and warning lights 1 (Not connected) 2 Low engine oil level (certain models) 3 (Not connected) 4 (Not

1986 Volvo 740 GL, GLE, Turbo Clean the contact surfaces on the wheel and hub. Lift the wheel and place it on the hub. Make sure that you align the wh

1986 Volvo 740 GL, GLE, Turbo 3. Remove Phillips screws and rim. Lift out the headlamp unit. 4. Disconnect the socket contact. Installation is done by

1986 Volvo 740 GL, GLE, Turbo 5 Turn the bulb holder clockwise to secure it. Check the bulb function. NOTE: It may be necessary to remove the washer f

1986 Volvo 740 GL, GLE, Turbo 5. Turn bulb holder clockwise. Check that bulb lights. Replace tail lamp inside cover. Bulbs Power CP(W) Socket US Bulb

1986 Volvo 740 GL, GLE, Turbo ● Check that the bulb lights ● Re-install cluster cover pg. 73 Replacing bulbs High-mounted brake light Remov

1986 Volvo 740 GL, GLE, Turbo Bulbs Power Socket Engine compartment light 10 W SV8.5 Trunk light (sedan models) Depress the catch with a screwdrive

1986 Volvo 740 GL, GLE, Turbo Bulbs Power Socket License plate light 4 W W 2.1 x 9.5d Courtesy light (wagon models) To remove bulb depress the sprin

1986 Volvo 740 GL, GLE, Turbo Interior light and reading lights Take hold of the front section of the light as shown and pull straight down. Replace

1986 Volvo 740 GL, GLE, Turbo Fog lights (certain models) Remove the Phillips screws securing the corner strips and pull out the reflector. Remove the

1986 Volvo 740 GL, GLE, Turbo It is necessary to remove the fuses to see if they are blown, see next page for information on fuses and related circuit

1986 Volvo 740 GL, GLE, Turbo Check the oil level indicator light before starting the car - it takes only a few seconds. The car should be standing on

1986 Volvo 740 GL, GLE, Turbo Location * Amperage1 Fuel pump, fuel injection system 252 Central locking, hazard warning flasher, headlight flashers

1986 Volvo 740 GL, GLE, Turbo *Some of the equipment/systems listed may be available on certain models only and/or as optional items only. pg. 79 Re

1986 Volvo 740 GL, GLE, Turbo pg. 80 Service diagnosis The diagnoses outlined below are intended to serve only as guides to locate and temporarily cor

1986 Volvo 740 GL, GLE, Turbo Intake system leaking.Check vacuum hose connections at manifold and auxiliary air valve. No fuel reaching engine.Check f

1986 Volvo 740 GL, GLE, Turbo Fuel filter clogged. Clean fuel tank filter and replace line fuel filter. Condition: Misfiring at highway driving speed

1986 Volvo 740 GL, GLE, Turbo 1 9 8 6 VOLVO 740 GL, GLE, Turbo Car care pg. 83 Car care Car care includes not only maintaining the appearance of the

1986 Volvo 740 GL, GLE, Turbo and causing the door to rust through at the bottom. ● Corrosion will be accelerated in areas of higher relative humi

1986 Volvo 740 GL, GLE, Turbo a. thin (ML), for seams under the car. b. thin (transparent) for visible pans. c. thick, for parts on the underbody and

1986 Volvo 740 GL, GLE, Turbo model plate. The plate is located on the panel above the right-side head lights. Minor stone chips and scratches Materi

1986 Volvo 740 GL, GLE, Turbo When the primer surface is dry, the paint can be applied using a brush. Mix the paint thoroughly: apply several thin pai